雨虹金裝美縫劑是一種室內瓷磚縫隙、廚衛器具邊角、陰角修飾材料，擁有瓷一般的質感，色彩靚麗。它有效解決了室內縫隙、邊角環境存在的易積塵、生菌發霉、污染變黑、不易清潔的難題，為室內環境的潔凈安全提供便利。

執行標準：Q/SYYHF0099-2019《瓷磚縫隙裝飾材料》

產品特點：防水防霉、抗污易潔；高性價比、法國A+環保產品

適用范圍:室內瓷磚、大理石等縫隙裝飾填充；廚衛器具固定、修邊；室內陰角美化。基層處理仔細清理施工基面、縫隙中的油漬、疏松物及其它污染物。

施工工藝:

1施工前準備：長沙防水公司施工前考察施工場地環境，對于不同顏色花紋的瓷磚進行配色，計算并準備好足夠數量、顏色適當的靚縫劑，并準備好靚縫劑施工所需工具。

2縫隙及面層處理：采用清縫錐或鏟刀等工具預先將縫隙中的油漬、疏松物及其他污染物進行清理并用掃帚進行清掃，然后使用粉塵吸塵器將瓷磚縫隙內部的粉塵吸干凈，瓷磚縫隙兩側2cm寬采用抹布擦洗干凈，保證瓷磚縫隙內不潮濕，無粉塵、顆粒、油漬、疏松物等，同時清潔瓷磚表面污染物，瓷磚為仿古磚或麻面磚等非光面磚或其他吸水磚，填縫前要打蠟或粘貼美紋紙。

3材料準備及工具安裝：選擇設計顏色的靚縫劑并檢測材料真偽、保質期，保證材料符合標準。根據縫寬用美工刀裁切專業混合管；在安裝膠嘴前，將靚縫劑少打出來一點可保證A、B組分同時出料，避免出現膠嘴混合不勻導致的無法固化現象，隨后安裝膠嘴擠壓去除前20cm的出料，使靚縫劑AB組分充分混合均勻。

4填縫施工：填縫施工時混合棒盡可能與瓷磚面呈45°角以便靚縫劑能充滿縫隙，緩緩用力將料均勻涂在縫中，并掌握好力度和頻率，均勻的向后移動混合管，保證瓷磚縫隙填充均勻飽滿。

5壓縫刮縫處理：為保證靚縫劑固化后瓷磚縫隙充分飽滿成適度的圓弧面，可采用專用壓縫球或調刀沿瓷磚縫隙均勻的用力從一端拉向另一端；若需靚縫劑固化后瓷磚縫隙充分飽滿成水平面，可采用美縫刮板或軟膠板沿瓷磚縫隙均勻的用力從一端拉向另一端，且不偏離美紋紙以防污染瓷磚表面。

6清潔處理：若采用美紋紙工藝，壓縫后5-10分鐘，即可揭掉美紋紙，清除周邊多余靚縫劑，擦去余漬。如采用未貼美紋紙工藝，待填縫施工12小時后，采用清潔鏟將瓷磚表面的半固化的靚縫劑清理干凈。清潔處理時，不得破壞裝飾面磚，以免影響整體施工美觀效果。

7成品保護與驗收：按照設計要求，進行施工驗收，要求填縫均勻飽滿不得有漏填現象且表面光滑平整。常溫下，24小時達到使用強度，自然養護7天。填縫后24小時內要避免受到污染、水沖，地面上避免行走。

注意事項:施工時須使用專用混合管、省力優質膠槍；靚縫劑施工時，較佳施工溫度為15～35℃，保持施工基層干燥，施工環境干燥；施工環境溫度較低時，可將靚縫劑放到熱水中浸泡預熱，減輕打膠阻力；施工時禁止材料受到污染；縫隙較深時需做打底背襯，預留2MM縫深。墊層一定要平整、結實、干燥、無粉塵、疏松物等，禁止采用質量較差的白水泥、水泥基填縫劑鋪底；仿古磚、麻(ma)面磚等非光面磚或其他吸水磚施工時需要打蠟或粘貼美紋紙處理；安裝混合管前將靚縫劑稍打出來一點，保證A、B組分同時出料；前20CM的出料不能填縫使用；開始打膠時速度要均勻，縫隙要填滿；空置30分鐘后再次使用時需更換膠管；混合管的出料寬度要與縫寬基本保持一致，保證面料完全覆蓋住瓷磚縫；大面積施工應按先填墻面縫隙，后填地面縫隙的原則；遇十字接口多的小磚施工時應按先填垂直縫，后填水平縫的原則；壓縫需要在填縫后30分鐘內完成；靚縫劑施工24小時后即可正常投入使用，24小時內不可有粉塵接觸磚縫上的靚縫劑；可用開水或吹風機加熱后用刀剔除固化后的膠料。